TEF6730A NXP Semiconductors, TEF6730A Datasheet
TEF6730A
Related parts for TEF6730A
TEF6730A Summary of contents
Page 1
... Front-end for digital-IF car radio Rev. 01 — 21 February 2007 1. General description The TEF6730A is a car radio tuner front-end for digital-IF reception, especially designed for co-operation with digital-IF DSP back-ends of the SAF773x and SAF778x families. The FM tuner features single conversion 10.7 MHz and integrated image rejection; ...
Page 2
... Front-end for digital-IF car radio Min Typ , 8.5 CC(RF) - 85.3 - 114.7 0 100 [ [3] Figure [3] 256 - 0. 144 - 522 - 2 10 TEF6730A Max Unit 1.35 - kHz 130 MHz 159.9 MHz - MHz - dBc 6.5 ms 288 kHz 1710 kHz 26.1 MHz - MHz - V © NXP B.V. 2007. All rights reserved ...
Page 3
... AGC bits NBAGC[1: 400 kHz 100 Hz; CC(ripple) audio ripple (RMS); CC(ripple 500 V i(RF 1.915 -------- - + 0.1 DAAOUT 1 128 Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ - 125 - 100 - 200 - 170 - 140 - 115 - 152 - 130 - ...
Page 4
... Hz, de-emphasis = mod Description plastic thermal enhanced thin quad flat package; 64 leads; body mm; exposed die pad Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio V where 15. DAAOUT 1 = 400 Hz, 2.5 kHz audio bandwidth 97.1 MHz 22.5 kHz, i(RF) = 990 kHz ...
Page 5
... DAAOUT1 29 WXMIXDEC 28 MIXER 90 WXMIXIN WX 27 FMMIXIN2 26 FMMIXIN1 ifagc 30 IFMAGC AGC AGC Fig 1. Block diagram of TEF6730AHW vref sup sup fgnd REF BAND f M ref tuner control TEF6730AHW MIXER 90 FM ifagc MIXER AM LNA lna lna rf ...
Page 6
... IF AGC amplifier AM and FM decoupling 5 ceramic filter switch decoupling 6 ceramic filter switch 1 7 ceramic filter switch mixer IF output 1 (10.7 MHz mixer IF output 2 (10.7 MHz) Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio TEF6730AHW 48 i.c. 47 ADDR1 46 ADDR2 45 FGND 44 AFHOLD 43 AFSAMPLE 42 ...
Page 7
... I C-bus data line input and output Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio © NXP B.V. 2007. All rights reserved ...
Page 8
... IF AGC amplifier ground 64 bias voltage decoupling for IF AGC amplifier 2 C-bus independently of the band selection. A separate Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio 2 C-bus and uses the in-band level information © NXP B.V. 2007. All rights reserved ...
Page 9
... I C-bus protocol S SLAVE ADDRESS W Fig 3. Write mode TEF6730A_1 Product data sheet ACK-s ACK-s MSA Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio 2 C-bus. The ACK-s P DATA data transferred (n bytes acknowledge) 001aad051 © NXP B.V. 2007. All rights reserved ...
Page 10
... STOP condition 2 C-bus register at the preceding acknowledge clock pulse. Name TUNER TAS1 TAS0 - Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio ACK-m DATA Reference Section 8.1.1 Section 8.1 © NXP B.V. 2007. All rights reserved 001aad049 ...
Page 11
... PLL tuning ready and mute activated at DSP - not used POR power-on reset 0 = normal operation C-bus data is reset to default POR state; POR is reset to logic 0 after the TEF6730A has been read out and written to via 2 I C-bus at least once ID - data byte 1h bit allocation ...
Page 12
... Product data sheet 2 C-bus data is not loaded into the CONTROL register directly 2 C-bus transmission time, only bytes that include data changes need to Figure 6). Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio 2 C-bus data. Action progress is monitored by 2 C-bus remains Figure 7). ...
Page 13
... PLLL DAA AGC BAND TEST MODE MODE DECODER AFSAMPLE STATE MACHINE AFHOLD 2 C-bus control Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Default Reference 0000 0100b Section 8.2.2 0000 1000b Section 8.2.3 0111 1110b Section 8.2.4 0100 0000b Section 8.2.5 1000 0000b Section 8.2.6 0010 0000b Section 8 ...
Page 14
... Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio byte 3 byte 4 byte 5 P new new new new swap © NXP B.V. 2007. All rights reserved. current current current ...
Page 15
... Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio byte 4 byte 5 P new new new swap © NXP B.V. 2007. All rights reserved. current current current current current ...
Page 16
... Figure 9, Figure 11, 2 > Between the end of the I C-bus transmission and the falling edge of the AFHOLD pulse necessary. Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio SA3 SA2 Figure 6 2 C-bus write); see Figure 7 [2] ...
Page 17
... I C-bus P time PLL tuning f1 f2 '11' '11' '10' TAS read AFHOLD 50 s AFSAMPLE Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio 60 ms '11' '11 suggested IF DSP signal control FAST 60 ms '11' '00' 001aae097 '00' 001aae098 © NXP B.V. 2007. All rights reserved ...
Page 18
... AFHOLD AFSAMPLE reset tuning mute reset 2 I C-bus P time PLL tuning f1 f2 '11' '11' '10' TAS read AFHOLD AFSAMPLE Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio '11' suggested IF DSP signal control FAST '11' 001aae099 '11' 001aae100 © NXP B.V. 2007. All rights reserved ...
Page 19
... I C-bus P 0.5 ms time PLL tuning f2 f1 '11' '10' TAS read '00' AFHOLD AFSAMPLE Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio 0 PLL f2 f1 '11' '10' '00' suggested IF DSP signal control store AFU result reset HOLD '00' 001aae101 '00' 001aae102 © NXP B.V. 2007. All rights reserved. ...
Page 20
... AFSAMPLE reset tuning mute HOLD 2 I C-bus P 0.5 ms time PLL tuning f1 f2 '11' '11' '10' TAS read '00' AFHOLD AFSAMPLE Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio 0.5 ms '11' '00' suggested IF DSP signal control '00' 001aae103 '00' 001aae104 © NXP B.V. 2007. All rights reserved ...
Page 21
... AFHOLD AFSAMPLE reset tuning mute HOLD 2 I C-bus P time PLL tuning f1 f2 '11' '11' '10' TAS read AFHOLD AFSAMPLE Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio '11' suggested IF DSP signal control '11' 001aae105 '11' 001aae106 © NXP B.V. 2007. All rights reserved ...
Page 22
... IF gain (6 dB) NBAGC[1:0] RF AGC start level; setting of narrow band (IF) detection 00 = 700 mV (peak value 560 mV (peak value 450 mV (peak value 350 mV (peak value) Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio suggested IF DSP signal control 3 2 NBAGC1 NBAGC0 DAASW ...
Page 23
... PLL divider word; PLL[14:0] is the divider ratio N of the VCO programmable divider 1024 to 32767 DAA - data byte 3h bit allocation with default setting DAA6 DAA5 DAA4 Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio …continued tune ) tune PLL11 PLL10 PLL9 1 ...
Page 24
... Setting of RF AGC threshold voltage for FM WBAGC0 FM mixer input voltage (RMS value) at FMMIXIN Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio ) WBAGC1 WBAGC0 KAGC DAAOUT1 Table 25 © NXP B.V. 2007. All rights reserved. ...
Page 25
... Reference frequencies FREF1 FREF0 30. Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio FREF1 FREF0 LOINJ Table 29 Divider ratio M Receiver band ...
Page 26
... TEST3 Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Charge pump current CP1 CP2 CP3 CP3 CP4 CP5 ref 0 0 100 kHz 100 kHz ...
Page 27
... AMMIXOUT1 and AMMIXOUT2 on pins ADDR1 and ADDR2 on pins AFHOLD and AFSAMPLE on pin SWPORT soldered exposed die pad subjective functionality full functionality on all pins except pin V CC(VCO) on pin V CC(VCO) . CCA Conditions Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Max , 0.3 +10 CC(RF) 0.3 +0.3 0.3 +5.5 0.3 +5.5 [1] ...
Page 28
... amb amb amb amb amb amb amb amb amb amb Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max ...
Page 29
... GND measured between each pin to GND 29, Table 30 and Table 31 application according to Figure 200 MHz kHz; VCO Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max - 21 ...
Page 30
... MHz AM MW band kHz; ref f = 0.53 MHz to 1.7 MHz RF cycle time for inaudible AF update including 1 ms mute start and 1 ms mute release time Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max - 2 - 130 180 240 240 180 ...
Page 31
... Hz; ripple V = 100 mV CC(ripple) AM mode and FM mode minimum value maximum value data byte AGC bits SDAA[3:0] = 1000; FM mode with frequency DAAOUT1 range from 300 kHz Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max - - 0 CC(PLL 0 ...
Page 32
... IFAGCMSB V = LOW; IFAGCLSB see Table 15 data byte CONTROL bits NBAGC[1: data byte CONTROL bits NBAGC[1: data byte CONTROL bits NBAGC[1: data byte CONTROL bits NBAGC[1: Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max 30 - +30 0.5V 0 +0.5V LSB LSB V - ...
Page 33
... IAMAGC FM mode; data byte DAA bit AGCSW = 1 FM mode; data byte DAA bit AGCSW = 0 on pin AMMIXIN compression point MIXOUT1-MIXOUT2 Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max - 111 ...
Page 34
... KAGC = 1; V > V KAGC th(KAGC) data byte AGC bits WBAGC[1: data byte AGC bits WBAGC[1: data byte AGC bits WBAGC[1: data byte AGC bits WBAGC[1: Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max - - - 135 138 - - 170 - - 7 ...
Page 35
... FM mixer output voltage R = 500 ; noise of source R included 2.6 k source L (on output pins FMMIXOUT1 and FMMIXOUT2) RFGAIN = 0 RFGAIN = 1 RFGAIN = 0 RFGAIN = 1 Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max 490 700 980 390 560 780 315 450 630 245 350 ...
Page 36
... C to +85 C; amb see Figure 300 source o(wanted) o(image 162.475 MHz; RF(wanted 183.875 MHz RF(image) [10] ; outputs: pins IFOUT1 and IFOUT2 Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max - 4.2 5 ...
Page 37
... CONTROL bit IFGAIN = LOW; IFAGCMSB V = LOW IFAGCLSB V = LOW; IFAGCMSB V = HIGH IFAGCLSB V = HIGH; IFAGCMSB V = HIGH IFAGCLSB V = HIGH; IFAGCMSB V = LOW IFAGCLSB Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max 21.2 24.2 27.2 15.2 18.2 21.2 9.2 12.2 15.2 3.2 6.2 9.2 27.2 30.2 33.2 21.2 24.2 27.2 15.2 18.2 21.2 9.2 12.2 15 ...
Page 38
... IFAGCMSB V = HIGH IFAGCLSB V = HIGH; IFAGCMSB V = LOW IFAGCLSB R = 300 ; data byte source CONTROL bit IFGAIN = LOW; IFAGCMSB V = LOW IFAGCLSB data byte CONTROL bit IFGAIN = 0 Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max 180 - - 360 - - [11] - 330 - - 5 ...
Page 39
... HIGH; IFAGCMSB V = HIGH IFAGCLSB V = HIGH; IFAGCMSB V = LOW IFAGCLSB R = 300 ; data byte source CONTROL bit IFGAIN = LOW; IFAGCMSB V = LOW IFAGCLSB data byte CONTROL bit IFGAIN = 0 Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max 160 - - [11] - 330 - - 5 7 ...
Page 40
... HIGH; IFAGCMSB V = LOW IFAGCLSB = 0 0 FLAG = 0 1.915 -------- - + 0.1 DAAOUT 1 128 0.693 ----- - + 0.7 DAAOUT 2 16 Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ 160 - - - 1.5 - 1.0 - 1 where 127. tune V where 15. DAAOUT 1 Max Unit - mV ...
Page 41
... Fig 21. FM mixer conversion transconductance gain deviation over temperature (including application) 2 13. I C-bus characteristics The TEF6730AHW complies with the fast-mode I communication speed is 400 kbit/s. SDA and SCL HIGH and LOW internal thresholds are specified according voltage range from 2 3.3 V including C-bus interface tolerates also SDA and SCL signals from bus ...
Page 42
... Figure 24 C 120 pF; see Figure C-bus line [pF]. [ns] depends on the total load capacitance resp(Q)LH 001aaf002 b. Data change from HIGH to LOW Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max - - 1.09 1. ...
Page 43
... AGC bits NBAGC[1: referenced to receiver input kHz f = 100 kHz 100 Hz; CC(ripple) audio ripple (RMS); CC(ripple i(RF) FM standard weather band Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio 001aab803 Min Typ Max 144 - 288 522 - 1710 2.3 - 26 ...
Page 44
... AGC bits NBAGC[1: data byte AGC bits NBAGC[1: 400 kHz 100 Hz; CC(ripple) audio ripple (RMS); V CC(ripple) i(RF) = 400 Hz, 2.5 kHz audio bandwidth, f mod = 400 Hz, de-emphasis = mod Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Min Typ Max - 1 ...
Page 45
... BAP70- 220 KEYED AGC 6 470 k 2 100 560 For list of components see Table 39. Fig 25. Application diagram of TEF6730AHW V +8 FREF 220 pll VCO VCO sup ...
Page 46
... FM PIN diode AM PIN diode 10.7 MHz IF ceramic filter TEF6730AHW Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio 28 TEF6730AHW 008aaa060 and Figure 26 Type Manufacturer 270 pF; type NP0 - 50 nH; E558CNA-100035 TOKO 100 nH; C2520C-R10 SAGAMI 470 nH; C2520C-R47 SAGAMI 220 nH ...
Page 47
... Product data sheet TEF6730AHW TEF6730AHW Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio IF AGC 330 330 FM/ 008aaa062 IF AGC 330 330 330 22 nF ...
Page 48
... Product data sheet and AM HD Typ Max 2.3 - 2.3 - 2.3 - 2.3 - 1.4 - 1.4 - 1.4 - 5.2 - Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio IF AGC 330 330 330 22 nF 008aaa064 FM mode Min Typ - 2.3 - 2.3 - 2.3 - 2.3 - 1.4 - 1.4 - 1.4 external 8.5 external 8.5 external 8.5 external 8.5 external 8.5 - 0.9 © ...
Page 49
... V 0.6 CC(PLL 0.7 CC(PLL) 6 8.5 - 8.5 5 Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio FM mode Min Typ - 0 0.8 floating floating floating - 1.1 external biasing external GND FM: 2.4; WB: 0 FM: 2.8; WB: 0 FM: 3.2; WB: 0 FM: 2.4; WB: 0 FM: 2.8; WB: 0 FM: 3.2; WB: 0 WB: 2.0; FM: 0 WB: 2.4; FM: 0 WB: 2.8; FM: 0 WB: 2.0; FM: 0 WB: 2.4; FM: 0 WB: 2.8; FM: 0 ...
Page 50
... GND IFAGCBIAS 64 - TEF6730A_1 Product data sheet …continued Typ Max 1.2 - 1.2 - 4.3 4.5 5.5 - 5.5 - 2.3 - Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio FM mode Min Typ - 1.2 - 1.2 4.1 4.3 external GND external 8.5 - 5.5 - 5.5 external 0 or external 3.3 external 0 or external 3.3 external 8.5 external GND - 2.3 © NXP B.V. 2007. All rights reserved. ...
Page 51
... Rev. 01 — 21 February 2007 Front-end for digital-IF car radio detail 12.15 12.15 0.75 1 0.2 0.08 11.85 11.85 0.45 EUROPEAN PROJECTION TEF6730A SOT855 (1) ( 1.45 1.45 7 0.1 1.05 1.05 0 ISSUE DATE 04-05-18 05-05-11 © NXP B.V. 2007. All rights reserved ...
Page 52
... Solder bath specifications, including temperature and impurities TEF6730A_1 Product data sheet Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio © NXP B.V. 2007. All rights reserved ...
Page 53
... Lead-free process (from J-STD-020C) Package reflow temperature ( C) 3 Volume (mm ) < 350 260 260 250 Figure 32. Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Figure 32) than a PbSn process, thus 350 220 220 350 to 2000 > 2000 260 260 250 245 ...
Page 54
... Product data sheet maximum peak temperature = MSL limit, damage level temperature minimum peak temperature = minimum soldering temperature MSL: Moisture Sensitivity Level Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio peak temperature time 001aac844 © NXP B.V. 2007. All rights reserved ...
Page 55
... Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio 13.650 (2 ) 12.200 (2 ) 10.400 (4 ) 9.035 (4 ) 7.900 (4 ) 0.400 (3 ) 10.250 (2 ) 12.400 (2 ) © NXP B.V. 2007. All rights reserved. 0.1425 ( ...
Page 56
... Weather Band 21. Revision history Table 44. Revision history Document ID Release date TEF6730A_1 20070221 TEF6730A_1 Product data sheet Data sheet status Change notice Product data sheet - Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio Supersedes - © NXP B.V. 2007. All rights reserved ...
Page 57
... Notice: All referenced brands, product names, service names and trademarks are the property of their respective owners C-bus — logo is a trademark of NXP B.V. http://www.nxp.com salesaddresses@nxp.com Rev. 01 — 21 February 2007 TEF6730A Front-end for digital-IF car radio © NXP B.V. 2007. All rights reserved ...
Page 58
... Please be aware that important notices concerning this document and the product(s) described herein, have been included in section ‘Legal information’. © NXP B.V. 2007. For more information, please visit: http://www.nxp.com For sales office addresses, please send an email to: salesaddresses@nxp.com TEF6730A All rights reserved. Date of release: 21 February 2007 Document identifier: TEF6730A_1 ...