tl5001-s08-t Unisonic Technologies, tl5001-s08-t Datasheet - Page 8

• Manufacturer Part Number: tl5001-s08-t
• Description: Low Operating Voltage Single Ended Pwm Ic
• Manufacturer: Unisonic Technologies

TL5001
SHORT-CIRCUIT PROTECTION (SCP)
damage when the converter output is shorted. When activated, The SCP prevents the switch from being turned on
until the internal latching circuit is reset. The circuit is reset by reducing the input voltage until UVLO becomes active
or until the SCP terminal is pulled to ground externally.
attempt to maintain the output voltage. SCP comparator 1 starts an RC timing circuit when COMP exceeds 1.5V.If
the short is removed and the error-amplifier output drops below 1.5V before time out, normal converter operation
continues. If the fault is still present at the end of the time-out period, the time sets the latching circuit and turns off
the UTC TL5001 output transistor.
towards 2.5V through a 185kΩ resistor (Rscp).The circuit begins charging from an initial voltage of approximately
185mV and times out when capacitor voltage reaches 1V.The output of SCP comparator 2 then goes high, turns on
Q2,and latches the timer circuit. The expression for setting the SCP time period is derived from the following
equation:
Where
The end of the time-out period, tscp, occurs when Vscp=1V. Solving for Cscp yields:
Where
start.
OUTPUT TRANSISTOR
a voltage rating of 51V.The output is turned on under the following conditions: the oscillator triangle wave is lower
than both the DTC voltage and the error-amplifier output voltage, the UVLO circuit is inactive, and the short-circuit
protection circuit is inactive.
The UTC TL5001 includes short-circuit protection (see Figure 3), which turns the power switch off to prevent
When a short circuit occurs, the error-amplifier output at COMP rises to increase the power-switch duty cycle in an
The timer operates by charging an external capacitor (Cscp),connected between the SCP terminal and ground,
tscp must be much longer (generally 10 to 15 times) than the converter start-up period or the converter will not
The output of the UTC TL5001 is an open-collector transistor with a maximum collector current rating of 21mA and
DETAILED DESCRIPTION(Cont.)
C
Vscp =(2.5-0.185)(1-e
ι=RscpCscp
Cscp=12.46*tscp
t is in seconds, C in µF
SCP
UNISONIC TECHNOLOGIES CO., LTD
www.unisonic.com.tw
5
SCP
From Error
Amp
1.5V
-t/ τ
)+0.185
Comparator 1
scp
Q2
2.5V
Figure 3.SCP Circuit
R
SCP
Q1
12kO
185kO
LINEAR INTEGRATED CIRCUIT
V
REF
Comparator 2
=1V
scp
QW-R103-016,C
Drive Logic
To Output
8 of 13