tea1610t NXP Semiconductors, tea1610t Datasheet
![no-image](/images/manufacturer_photos/0/4/487/nxp_semiconductors_sml.jpg)
tea1610t
Available stocks
Related parts for tea1610t
tea1610t Summary of contents
Page 1
... TEA1610P; TEA1610T Zero-voltage-switching resonant converter controller Rev. 03 — 26 March 2007 1. General description The TEA1610 is a monolithic integrated circuit implemented in a high-voltage Diffusion Metal Oxide Semiconductor (DMOS) process. The circuit is a high voltage controller for a zero-voltage switching resonant converter. The IC provides the drive function for two discrete power MOSFETs in a half-bridge confi ...
Page 2
... I f common mode input voltage and I CF(ch) Description plastic dual in-line package; 16 leads (300 mil); long body plastic small outline package; 16 leads; body width 3.9 mm; low stand-off height Rev. 03 — 26 March 2007 TEA1610P; TEA1610T I High voltage power supplies Min Typ 135 180 DD( ...
Page 3
... Zero-voltage-switching resonant converter controller BOOTSTRAP SUPPLY SHIFTER TEA1610 reset start/stop oscillation shut-down start- VCO IRS REF Rev. 03 — 26 March 2007 TEA1610P; TEA1610T 8 7 LEVEL HIGH SIDE DRIVER 6 10 LOW SIDE DRIVER 4 LOGIC 15 2.33 V ÷ charge OSCILLATOR I discharge ...
Page 4
... Rev. 03 — 26 March 2007 TEA1610P; TEA1610T VCO 3 PGND 4 TEA1610T 5 n. DD(F) 001aaf867 Fig 4. Pin configuration for TEA1610T © NXP B.V. 2007. All rights reserved REF IRS IFS SGND ...
Page 5
... V the start level. The start-up state is maintained until V activated and the converter starts operating. Fig 5. Start-up TEA1610T_P_3 Product data sheet TEA1610P; TEA1610T Zero-voltage-switching resonant converter controller reaches V DD DD(initial) reaches the start level (13.5 V), the oscillator is DD ...
Page 6
... V reference pin (V dt Figure 10). The voltage on the IFS pin is kept constant IFS dt Rev. 03 — 26 March 2007 TEA1610P; TEA1610T f (see Figure 10). The oscillator f Figure 6. dead time (low to high) t and the 2.4 V voltage drop across this resistor. The and determines the falling f ...
Page 7
... IRS2 IRS2 max 1 = ------------ - T OSC Rev. 03 — 26 March 2007 TEA1610P; TEA1610T pin (3 V reference voltage) and the IRS REF ) and the discharge current: IRS1 resistor which is connected between f increases and the oscillation frequency CF Figure 7 f(min) and determine the f © ...
Page 8
... IRS input of the current-controlled VCO and the minimum frequency setting is independent of the characteristics of f(min) Rev. 03 — 26 March 2007 TEA1610P; TEA1610T , the peak-to-peak f I IRS mgw001 , the initial switching frequency of the f © NXP B.V. 2007. All rights reserved. ...
Page 9
... V DD new start-up cycle can commence (see Fig 8. Shut-down TEA1610T_P_3 Product data sheet TEA1610P; TEA1610T Zero-voltage-switching resonant converter controller is clamped by an internal Zener diode at 12.0 V with DD rising above the rating due to low DD level (typically 5.3 V). The shut-down latch is then reset and a ...
Page 10
... REF total power dissipation ambient temperature storage temperature electrostatic discharge voltage 10, and in the application note). Thermal characteristics Parameter thermal resistance from junction to ambient thermal resistance from junction to pin Rev. 03 — 26 March 2007 TEA1610P; TEA1610T Conditions Min Max 0 600 [ ...
Page 11
... V IRS 200 A IRS IRS mA IFS IFS C = 100 pF 0.5 mA; F IFS f OSC ------------ - IRS bridge 2 Rev. 03 — 26 March 2007 TEA1610P; TEA1610T Min Typ Max - - 12.9 13.4 13.9 9.0 9.4 9.8 3.8 4.0 4.2 11.0 12.0 13.0 4.5 5.3 6.0 [1] 130 180 220 - 2 130 180 2 ...
Page 12
... 2. I(CM I(CM) VCO source only I(CM I(CM I(CM) Rev. 03 — 26 March 2007 TEA1610P; TEA1610T Min Typ Max [2] 450 500 550 - 1. 3.0 - 1.63 1.73 1.83 0.37 0.40 0.43 135 180 225 - 300 - 135 180 225 - 300 - 10 ...
Page 13
... VCO I = 0.3 mA VCO = 55 nC typ.) and these will increase the supply current at 150 kHz g(tot) 2 55nC 150kHz = 16.5mA , the peak-to-peak voltage swing V f Rev. 03 — 26 March 2007 TEA1610P; TEA1610T Min Typ Max [3] 3.2 3.6 4.0 0.4 0.5 0.6 2.3 2.5 2.7 , and the charge/discharge CF © NXP B.V. 2007. All rights reserved. ...
Page 14
... Note that the slope of the measured frequency differs from the theoretical IRS dead time (high to low) frequency set 80 Rev. 03 — 26 March 2007 TEA1610P; TEA1610T voltage is pulled below the stop DD and C . The minimum The output voltage ...
Page 15
V R VDD C VDD 7 on/off bootstrap diode TEA1610 SUPPLY signal ground SGND 9 regulator feedback ERROR AMPLIFIER 3 VCO ...
Page 16
... NXP Semiconductors 13. Test information 13.1 Quality information The General Quality Specification for Integrated Circuits, SNW-FQ-611 is applicable. TEA1610T_P_3 Product data sheet TEA1610P; TEA1610T Zero-voltage-switching resonant converter controller Rev. 03 — 26 March 2007 © NXP B.V. 2007. All rights reserved ...
Page 17
... 1.40 0.53 0.32 21.8 6.48 1.14 0.38 0.23 21.4 6.20 0.021 0.013 0.86 0.26 0.055 0.015 0.009 0.045 0.84 0.24 REFERENCES JEDEC JEITA MO-001 SC-503-16 Rev. 03 — 26 March 2007 TEA1610P; TEA1610T 3.9 8.25 9.5 2.54 7.62 3.4 7.80 8.3 0.15 0.32 0.37 0.1 0.3 0.13 0.31 0.33 EUROPEAN PROJECTION © NXP B.V. 2007. All rights reserved. ...
Page 18
... 0.49 0.25 10.0 4.0 1.27 0.36 0.19 9.8 3.8 0.019 0.0100 0.39 0.16 0.244 0.05 0.014 0.0075 0.38 0.15 0.228 REFERENCES JEDEC JEITA MS-012 Rev. 03 — 26 March 2007 TEA1610P; TEA1610T detail 6.2 1.0 0.7 1.05 0.25 0.25 5.8 0.4 0.6 0.039 0.028 0.041 0.01 0.01 ...
Page 19
... Data sheet status Product data sheet Table 4 “Limiting values”, maximum value for V Product data sheet Section 8.4 “Minimum frequency resistor” resistor”. Product specification Rev. 03 — 26 March 2007 TEA1610P; TEA1610T Change notice Supersedes - TEA1610T_P_2 changed from TEA1610T_P_1 and Section 8.5 “ ...
Page 20
... Trademarks Notice: All referenced brands, product names, service names and trademarks are the property of their respective owners. http://www.nxp.com salesaddresses@nxp.com Rev. 03 — 26 March 2007 TEA1610P; TEA1610T © NXP B.V. 2007. All rights reserved ...
Page 21
... Please be aware that important notices concerning this document and the product(s) described herein, have been included in section ‘Legal information’. © NXP B.V. 2007. For more information, please visit: http://www.nxp.com For sales office addresses, please send an email to: salesaddresses@nxp.com All rights reserved. Date of release: 26 March 2007 Document identifier: TEA1610T_P_3 ...